Eclipse 508 Servisní příručka

DCB, DCFCB, and DCFCTB Models Battery Operated 2001 Siren Control System with Federal Controller, One-Way and Two-Way Series B (FCT) Installat

3 Safety Message DCB, DCFCB and DCFCTB Models Operation Failure to understand the capabilities and limitations of your siren system could result in

93 Figure 29 DCFCB Final Assembly

94 Figure 30 DCTB-PGE Wiring

95 Figure 31 DCTB-PGE Final Assembly

Glossary MERGEFORMAT ConfiguGlossaryal Descriptionations DCB, DCFCB and DCFCTB Models 96 Glossary Term Description AC Electric Alternating Current

Glossary MERGEFORMAT ConfiguGlossaryal Descriptionations DCB, DCFCB and DCFCTB Models 97 Term Description SFCDWARE Federal Commander Digital System

Index MERGEFORMAT ConfiguIndexal Descriptionations DCB, DCFCB and DCFCTB Models 98 Index + +12 VDC ...

Index MERGEFORMAT ConfiguIndexal Descriptionations DCB, DCFCB and DCFCTB Models 99 Ethernet Board Specifications...

Index MERGEFORMAT ConfiguIndexal Descriptionations DCB, DCFCB and DCFCTB Models 100 Sensors and Sensor Inputs ...

2645 Federal Signal Drive, University Park, IL 60484-3167 Phone: 800-524-3021 E-mail: [email protected] Website:

4 Characteristics DCB, DCFCB and DCFCTB Models Characteristics Scope of this Manual This manual describes the characteristics, specifications, func

5 Characteristics DCB, DCFCB and DCFCTB Models The antenna system is not included with the radio controller models. The appropriate directional or

6 Characteristics DCB, DCFCB and DCFCTB Models The DCFCTBs contain six user programmable functions in addition to the five preset functions: ARM, D

7 Characteristics DCB, DCFCB and DCFCTB Models used as a Civil Defense “Alert” signal. The Wailing signal is often used as a Civil Defense “Attack”

8 Specifications DCB, DCFCB and DCFCTB Models Specifications Specifications for the Controllers Input Power Requirements Input Power Requirements

9 Specifications DCB, DCFCB and DCFCTB Models Charging System and Recommended Batteries Chargers (one per battery) Charger Output Voltage 13.50 VD

10 Specifications DCB, DCFCB and DCFCTB Models Serial Communications Serial Communications Serial Port Configuration RS232C 1200,N,8,1 Signaling F

11 Specifications DCB, DCFCB and DCFCTB Models POCSAG Supports Binary frequency shift keying 512 Baud numeric messages. Inputs and Outputs Relay Ou

12 Functional Description DCB, DCFCB and DCFCTB Models Functional Description System Operating Description Siren Activation The DTMF versions of DC

Limited Warranty The Alerting and Notification Systems Division of Federal Signal Corporation (Federal) warrants each new product to be free from defe

13 Functional Description DCB, DCFCB and DCFCTB Models Control Cabinet Functional Descriptions The DC Control cabinet has the following main parts:

14 Functional Description DCB, DCFCB and DCFCTB Models TB3 1 12 VDC from Converter 2 12 VDC from Converter TB4 1 48 VDC TB5 F1 10 Amp fuse for

15 Functional Description DCB, DCFCB and DCFCTB Models Communications/Controller Board Layout ACFCTB Communications / Controller Board Layout Refer

16 Functional Description DCB, DCFCB and DCFCTB Models JP4 Test Speaker 1 VCC, +5 V 2 VCC, +5 V 3 Short pins 1 and 3 to give priority to the extern

17 Functional Description DCB, DCFCB and DCFCTB Models JP9 LEDs on with Intrusion 1 Short to pin 2, to disable LEDs when Intrusion switch is close

18 Functional Description DCB, DCFCB and DCFCTB Models For 2001 DC Non-Solar mode AC (Power) AC Power and External AC power (not looking at 48VDC)

19 Functional Description DCB, DCFCB and DCFCTB Models JP12 SINAD 1 Directly to processor pin #58 (ADC7). 2 Ground. JP13 CTCSS Encoder/Decoder 1

20 Functional Description DCB, DCFCB and DCFCTB Models JP20 Short to Test Relay Output #4 1 Short to pin 2, to engage Relay output #4. JP21 Relay

21 Functional Description DCB, DCFCB and DCFCTB Models TP1 Two-Tone Decoder, HighPass Filter Enable Goes high when processor is decoding a tone &g

22 Functional Description DCB, DCFCB and DCFCTB Models TP14 Ground TP15 12 Volt Regulated power supply TP16 Isolated +12 Volt Regulated power sup

DCB, DCFCB and DCFCTB Models Contents SAFETY MESSAGE ...

23 Functional Description DCB, DCFCB and DCFCTB Models S6 Site Address Switch Sets units site number Unit Address The unit address sets the sire

24 Functional Description DCB, DCFCB and DCFCTB Models Figure 3 Communications/Controller Board Layout

25 Functional Description DCB, DCFCB and DCFCTB Models Transceiver Interface A transceiver may be interfaced through the male DB9 connector, P1. Po

26 Functional Description DCB, DCFCB and DCFCTB Models Carrier Detect Carrier Detect input requires a pull to ground to indicate when carrier is pr

27 Functional Description DCB, DCFCB and DCFCTB Models  Proximity Switch Rotation Sensor Input: JP5-7 is used to connect a proximity switch to de

28 Functional Description DCB, DCFCB and DCFCTB Models #3 is reserved for a 2001AC disconnect option. Relay #4 is reserved for the low voltage cuto

29 Functional Description DCB, DCFCB and DCFCTB Models JP10 Pin-out Pin #11 FUNCTION #1 Pin #12 common Control Board Power Input The controller has

30 Theory of Operation DCB, DCFCB and DCFCTB Models Theory of Operation Control Board Theory of Operation Description of DCFCTB Block Diagram Power

31 Theory of Operation DCB, DCFCB and DCFCTB Models The unit contains an eight-position dipswitch for setting the unit’s site address. Remote Activ

32 Theory of Operation DCB, DCFCB and DCFCTB Models If the "INT" side is jumpered then the on-board receiver has priority. When it assert

DCB, DCFCB and DCFCTB Models Control Cabinet Functional Descriptions ...

33 Theory of Operation DCB, DCFCB and DCFCTB Models POCSAG Decode All POCSAG messages contain a Receiver Identity Code (RIC) or CAP code. This indi

34 Theory of Operation DCB, DCFCB and DCFCTB Models are all normally open with contact ratings up to 5 Amps and 240 Volts AC RMS. K3 and K4 outputs

35 Figure 5 DCFCTB Block Diagram

DCB, DCFCB and DCFCTB Models Theory of Operation 36 Software Description of DCFCTB Encoding Format The DCFCTB encodes a nine (9) digit DTMF string

DCB, DCFCB and DCFCTB Models 37 Theory of Operation Table 3 Function currently running DTMF Character Function 0 Standby 1 Function 1 2 Function 2

DCB, DCFCB and DCFCTB Models 38 Theory of Operation Example Received DTMF report string * C 1 D D 2 05 * * Starting character C Unit type DCFCTB w

DCB, DCFCB and DCFCTB Models 39 Theory of Operation through which C4 is charged to 4.0 Volts, and this voltage is applied to the non-inverting inpu

DCB, DCFCB and DCFCTB Models 40 Theory of Operation results in an active high applied to J1-2, indicating that the sensed current is outside the ac

DCB, DCFCB and DCFCTB Models 41 Theory of Operation Table 7 Parts List FEDERAL PART NO. LOCATION DESCRIPTION 107A907A C1,C2,C5 CAPACITOR, MONO, 3

DCB, DCFCB and DCFCTB Models 42 Theory of Operation Connectors JP1 Current Measurement Pass-Through 1 (+) voltage source 2 0-5 Amp (for gear driven

DCB, DCFCB and DCFCTB Models Control and Battery Box Installation ...

DCB, DCFCB and DCFCTB Models 43 Theory of Operation Figure 7 Rotator Motor Current Sensor Board Schematic 2005221B Battery Charger Theory of Opera

DCB, DCFCB and DCFCTB Models 44 Theory of Operation Circuit Description The charger implements a three-stage charging algorithm. The three stages a

DCB, DCFCB and DCFCTB Models 45 Theory of Operation above the 10 Volt threshold. Current is applied until the battery voltage rises to 13.5 Volts.

DCB, DCFCB and DCFCTB Models 46 Theory of Operation Figure 8 Charger Schematic

DCB, DCFCB and DCFCTB Models 47 Programming Software Programming Software FSPWARE FSPWARE is a Microsoft Windows® based programming software for tw

DCB, DCFCB and DCFCTB Models 48 Installation Installation Electrocution or severe personal injury can occur when making electrical connections, dr

DCB, DCFCB and DCFCTB Models 49 Installation Figure 9 Typical DCFCB or DCFCTB with 2001TRB Installation Drawing

DCB, DCFCB and DCFCTB Models 50 Installation Control and Battery Box Installation The control and battery box is attached to a length of 5” channe

DCB, DCFCB and DCFCTB Models 51 Installation 24. 1‖ LB’s withgaskets and covers (1‖ raceway/cabinet-siren) 2 ea. 25. Split bolts, 10 AWG wire (2001

DCB, DCFCB and DCFCTB Models 52 Installation Pole Mounting 1. Remove any batteries from the battery box before lifting the control/battery box. 2.

DCB, DCFCB and DCFCTB Models Solar Power ...

DCB, DCFCB and DCFCTB Models 53 Installation Electrical Connections Install the siren electrical system in compliance with local electrical codes

54 Figure 10 DCFCTB Wiring Diagram

55 Figure 11 DCB Wiring Diagram

56 Figure 12 DCFCB Wiring Diagram

DCB, DCFCB and DCFCTB Models 57 Installation Siren Connections The complete system wiring diagrams are shown in Figure 10 DCFCTB Wiring Diagram, Fi

Installation 58 DCB, DCFCB and DCFCTB Models AC Power Connections TO PREVENT DAMAGE TO THE CONTROL UNIT, DO NOT CONNECT 240VAC POWER WITHOUT A MO

Installation 59 DCB, DCFCB and DCFCTB Models HTR4 (Battery Warmers) section on page 81 and Figure 21 HTR2 and HTR4 Wiring Diagram). 2. There are

Installation 60 DCB, DCFCB and DCFCTB Models Land Line Control You may activate the controller by applying contact closures to the remote activati

Installation 61 DCB, DCFCB and DCFCTB Models 3. Insert the elements into their respective locations through the boom, starting with R1 (the refle

Installation 62 DCB, DCFCB and DCFCTB Models D. Return to the dimensions shown in table 1 if there is any trouble achieving a good match. If the

DCB, DCFCB and DCFCTB Models Figure 28 DCB Final Assembly ...

Installation 63 DCB, DCFCB and DCFCTB Models If the VSWR specification is unattainable, replace the cable (A simple ohm meter check of the cable d

Installation 64 DCB, DCFCB and DCFCTB Models Figure 14 Yagi Antenna Installation Example

Installation 65 DCB, DCFCB and DCFCTB Models Figure 15 Omni Antenna Installation Example

Installation 66 DCB, DCFCB and DCFCTB Models Figure 16 Antenna Grounding

Pre-operational System Testing 67 DCB, DCFCB and DCFCTB Models Pre-operational System Testing The output sound level of a siren is capable of cau

Pre-operational System Testing 68 DCB, DCFCB and DCFCTB Models Activate a siren function by momentarily depressing one of the function pushbuttons

Pre-operational System Testing 69 DCB, DCFCB and DCFCTB Models indicated, follow up by load testing each battery with an automotive type battery l

Pre-operational System Testing 70 DCB, DCFCB and DCFCTB Models DTMF Transmit Level Adjustments (DTMF versions of DCFCTB only) 1. To Transmit and

Pre-operational System Testing 71 DCB, DCFCB and DCFCTB Models *Note: Deviation levels are cut in half on 12.5 kHz spaced channels. 3. Encode the

Service and Maintenance 72 DCB, DCFCB and DCFCTB Models Service and Maintenance The siren has moving parts, high operating current, explosive gas

Safety Message DCB, DCFCB and DCFCTB Models 1 Safety Message It is important to follow all instructions shipped with this product. This device is

Service and Maintenance 73 DCB, DCFCB and DCFCTB Models 3. Poll the system for siren status reports. 4. Examine each site report for any failed

Options 74 DCB, DCFCB and DCFCTB Models Options Model 2001TRB This option uses a transformer/rectifier for primary system power with battery back-

Options 75 DCB, DCFCB and DCFCTB Models Figure 17 Schematic Diagram 2001TRB When wiring the Model 2001TRB to control unit, installer must follo

Options 76 DCB, DCFCB and DCFCTB Models lock ring. Put a 1” plastic bushing over the exposed thread end on the 1” connector. 7. Cut a section of

Options 77 DCB, DCFCB and DCFCTB Models 220 VAC operation Service disconnect Transformer Transformer Primary: 2 ea. #10 black wires L1 H1 L2 H3

Options 78 DCB, DCFCB and DCFCTB Models Figure 18 Transformer Rectifier Wiring to Control Unit 5421 310 10F1F2A A

Options 79 DCB, DCFCB and DCFCTB Models Figure 19 2001TRB Transformer Rectifier Parts List Model -240B (Stepdown Transformer) This option allows t

Options 80 DCB, DCFCB and DCFCTB Models -240B Specifications Input Voltage 230 VAC, 50-60 Hz, single phase Output Voltage 115 VAC, 50-60 Hz, sin

Options 81 DCB, DCFCB and DCFCTB Models 3. Connect Ground (green wire) from fused disconnect to the green ground block on the DIN rail in the Con

Options 82 DCB, DCFCB and DCFCTB Models Model 2001HR (Holding Relay) This option enables the control of both of the siren motors from a single con

2 Safety Message DCB, DCFCB and DCFCTB Models  The sound output of sirens is capable of causing permanent hearing damage. To prevent excessive ex

83 Figure 22 DCFCTB Solar Wiring

84 Figure 23 DCB and DCFCB Solar Wiring

Model DCFCTBD-IP MERGEFORMAT Configuring the Informer-IPFORMAT General Descriptionations DCB, DCFCB and DCFCTB Models 85 Model DCFCTBD-IP General T

DCB, DCFCB and DCFCTB Models 86 Model DCFCTBD-IP MERGEFORMAT Configuring the Informer-IPFORMAT General Descriptionations JP4 RS232 Serial Port 1 -

DCB, DCFCB and DCFCTB Models 87 Model DCFCTBD-IP MERGEFORMAT Configuring the Informer-IPFORMAT General Descriptionations Physical Dimensions ~ 2‖

DCB, DCFCB and DCFCTB Models 88 Model DCFCTBD-IP MERGEFORMAT Configuring the Informer-IPFORMAT General Descriptionations IP Address User selectable

89 Figure 25 DCFCTB-IP Final Assembly

90 Figure 26 DCFCTB-IP Wiring Diagram

91 Figure 27 DCFCTB Final Assembly

92 Figure 28 DCB Final Assembly